|
|
|
Return to DOE Reports Table of Contents - F Return to TVA Coal-Gasification Commercial Demonstration Plant Table of Contents TVA Coal-Gasification Commercial Demonstration Plant Project. Volume 6. Plant Based on Gasifier. Final Report - November 1, 1980. Foster Wheeler Energy Corporation. Table of Contents 1.0 Introduction 2.0 Process Selection 2.1 Choice of Processing Sequence 2.2 General Description of Flow 2.3 Nominal Capacities of Processing Units 2.4 Block Flow Diagram 3.0 Baseline Design 3.1 Section 100 Coal Preparation Description of Flow List of Major Equipment Flow Diagram 3.2 Section 200 Air Separation Plant Description of Flow Input/Output Major Stream Flows List of Major Equipment Flow Diagram 3.4 Section 400 Acid Gas Removal Description of Flow Input/Output Major Stream Flows List of Major Equipment Flow Diagram 3.5 Section 600A – Clause Sulfur Recovery Plant Description of Flow List of Major Equipment Input/Output Major Stream Flows Flow Diagram Section 600B Sulfur Recovery Beavon Unit Description of Flow List of Major Equipment Flow Diagram 3.6 Section 700 Sour Water Stripper and Waste Water Treatment Description of Flow Flow Diagram 3.7 Section 800 Slag Handling Description of Flow List of Major Equipment Flow Diagram 3.8 Section 1200 Utility Area Raw Water Treatment and Storage Description of Flow List of Major Equipment Flow Diagram Potable Water Treatment Description of Flow List of Major Equipment Flow Diagram BFW Treatment Description of Flow List of Major Equipment Flow Diagram Steam Generation Description of Flow List of Major Equipment Flow Diagram 3.9 Section 1300 Cooling Water System Description of Flow List of Major Equipment Flow Diagram 3.10 Section 1400 - Flare Description of Flow List of Major Equipment Flow Diagram 3.11 Section 1500 - Waste Water Treatment Description of Flow List of Major Equipment Flow Diagram 3.12 Section 2000 - General Facilities Ash & Slag Storage By-Products and Chemicals Storage Firewater System Sewage System Power, Lighting and Communications 3.13 Section 2100 - Buildings 4.0 Plant Requirements 4.1 Summary of Feed and Products Tabulation of Feed and Products Overall Material and Energy Balance 4.2 Steam Balance Description of Flow Steam Balance Diagram 4.3 Cooling Water Usage Cooling Water Usage Diagram 4.4 Power Requirements Listing of Power Usage by Section 4.5 Fuel Requirements Discussion 4.6 Catalysts and Chemicals Requirements Catalyst & Chemical Cost 5.0 Plant Layout Key Plot Plan Elevations 6.0 Environmental Assessment 7.0 Suggestions for Follow-on Work 8.0 Projections 9.0 Cost Estimates 9.1 Investment Cost 9.2 Operating Cost 9.3 Sensitivity Analysis | |||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||